Cam Sensor DTCs - keywords P0107 P0452 P0522 P0532 P0641
| Subject: | Cam Sensor DTCs |
| Models: | 2007 Chevrolet Malibu, Impala, Monte Carlo, Uplander |
| 2007 Pontiac G6, Montana SV6 |
| 2007 Buick Terraza |
| 2007 Saturn Aura, Relay |
| Equippped with 3.5L LZ4, LZE, or 3.9L LZ8, LZ9 engine |
This PI was superseded to update models. Please discard PIP4102.
The following diagnosis might be helpful if the vehicle exhibits the symptom(s) described in this PI.
Condition/Concern:
The following diagnosis might be helpful if the vehicle exhibits the symptom(s) described in this PI.
Recommendation/Instructions:
The wires are coming off the side of the cam sensor connector forcing the red wire to sit high. The power steering pump sits right on top of this connector. You cannot see it with everything in place. To verify complaint (if concern is not occurring) wiggle/tug on the C130 connector (connector is mounted in bracket attached to upper front passenger side of the intake manifold). When the pump is removed you may find the red wire smashed and rubbed through on the pump bottom.
Important: If you find that the cam sensor wiring has been damaged please contact Jim Kelly at (586) 492-5612 and supply him with the VIN and mileage from the vehicle.
Repair following eSI wiring repair procedure.
Please follow this diagnostic or repair process thoroughly and complete each step. If the condition exhibited is resolved without completing every step, the remaining steps do not need to be performed.
